The Jack's Small Engines Forum - Join Our Online Community
Reply to post

Help Adjusting Governor Tecumseh H35

Author
a1parrothead
New Member
  • Total Posts : 3
  • Scores: 0
  • Reward points: 0
  • Joined: 2025/06/06 20:01:27
  • Status: offline
2025/06/06 20:18:56 (permalink)
0

Help Adjusting Governor Tecumseh H35

I am working on a Troy Bilt Chipper with an H#% engine. When starting it revs full throttle, and yes, I know the governor could be shot, But, I want to make sure. This is a simple set-up with no throttle control lever to adjust engine speed. The carb is clean with all parts moving freely. 
When off the governor is holding the throttle wide open and that does not change when I start it. Just full revving unless I manually move the throttle on the carb.
I just want to try and make sure I adjust the governor before tearing into the engine to see if its shot.
I know I hold the throttle wide open and loosen the screw holding the governor lever arm. But, using pliers, which way do I turn the internal arm sticking out of the crankcase? Clockwise or counter clockwise while holding the throttle open? 
This does not have a nut on the arm. It has a slotted screw to losson the arm so you can rotate the internal governer shaft slightly either way. 
Any help would be appreciated
Jeff

Attached Image(s)

4 Replies Related Threads

    SRTsFZ6
    Super Member
    • Total Posts : 2222
    • Scores: 80
    • Reward points: 0
    • Joined: 2018/11/18 07:20:58
    • Status: offline
    Re: Help Adjusting Governor Tecumseh H35 2025/06/06 21:01:32 (permalink)
    0
    The direction the throttle would move for WOT, 
    loosen the lock nut and turn the internal, (that goes into the engine) in the same direction
    as if it was opening the throttle.  Then tighten the nut.
     
    If you do it the opposite way, the throttle won't open at all...
     
    And yes, with the engine off, the governor arm will push the throttle wide open.
    Once started, the internal part pushes the throttle back to normal RPMs..
     
    Plz post back how it goes..
     
    .

    Scott
    a1parrothead
    New Member
    • Total Posts : 3
    • Scores: 0
    • Reward points: 0
    • Joined: 2025/06/06 20:01:27
    • Status: offline
    Re: Help Adjusting Governor Tecumseh H35 2025/06/06 21:44:56 (permalink)
    0
    Scott,
       Thank you. That spring that goes from the governor arm to under the carb somewhere is what seems to be keeping the governor arm pulled towards the carb and keeping the throttle wide open. With that said, if I take that spring off temporarily, so there is no external force pulling on the arm, is there anything diagnostic I could feel by moving the governor arm back and forth? Something that would give me a second clue (besides the high revving) that its an internal problem?
    SRTsFZ6
    Super Member
    • Total Posts : 2222
    • Scores: 80
    • Reward points: 0
    • Joined: 2018/11/18 07:20:58
    • Status: offline
    Re: Help Adjusting Governor Tecumseh H35 2025/06/07 06:46:22 (permalink)
    0
    If it's adjusted properly and still over revving, there's no other tests I know of
    W/O pulling the sump cover (or side cover) for a visual of the governor itself.
     
    A side cover gasket is cheap, to peek inside.  I'd pick one up, then if the 
    governor is needed, get that later..
     
    .
     
     

    Scott
    a1parrothead
    New Member
    • Total Posts : 3
    • Scores: 0
    • Reward points: 0
    • Joined: 2025/06/06 20:01:27
    • Status: offline
    Re: Help Adjusting Governor Tecumseh H35 2025/06/07 09:45:35 (permalink)
    0
    Thanks Scott. Time to tear apart the chipper!
    Jeff
    Jump to:
    Copyright © 1994 - 2016 Jacks Small Engine & Generator Service, LLC
    © 2025 APG vNext Trial Version 5.5